Lanier Worldwide, Inc.
2300 Parklake Drive, NE
Atlanta, GA USA 30345-2979
MATERIAL SAFETY DATA SHEET
Emergency Telephone: 800-551-3087
Section 1: Chemical Product and Company Information
Identity:
Product ID:
MSDS No.
Issued: 10/19/2006
Black Toner Type 140
CP- 458
480-0264
Supersedes:
10/31/2005
10/19/2006
EH&S Department 770-496-9500
Synonyms
& Common
Names:
Date:
Prepared by:
Black Toner Type 140
Lanier LP031c, AC031cn
Mixture
Approved by: Larry Choskey, H&S Manager
Uses:
Chemical
Formula:
Section 2: Composition / Information on Ingredients
PERCENT
CAS No.
Confidential
1333-86-4
EXPOSURE LIMITS
SOURCE
N/a
OSHA TWA
ACGIH TWA
N/a
Polyester resin
Carbon black
> 80
Not listed
1 – 10
3.5 mg/m3
3.5 mg/m3
Not listed
Wax
Silica
Organic salt
< 5
< 5
< 3
8015-86-9
Confidential
Confidential
Not listed
N/a
N/a
Not listed
*PEL as the product: 15mg/m3 (total dust), 5mg/m3 (respirable dust)
*TLV as the product: 10mg/m3 (total dust), 5mg/m3 (respirable dust)
Section 3: Hazards Identification
HMIS Rating:
FLAMMABILITY = 1
REACTIVITY = 0
HEALTH = 1
SPECIAL = none
Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure
to any non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic): Prolonged inhalation of excessive dust may cause lung damage. It is
attributed to “lung overloading”, a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval.
Use of this product, as intended, does not result in inhalation of excessive dust.
Carcinogenicity: Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation
study in rats. However, there was not observed the incidence of tumors on the test results on dermal or oral studies. Also, 2-years
inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors.
Section 4: First Aid Measures
Gargle with water. Remove to fresh air if effects
In case of contact, immediately flush eyes
with water for 15 minutes. Get medical
attention if needed.
Dilute stomach contents with several
glasses of water. Get medical attention.
occur. Get medical attention if needed.
Inhalation:
Eye Contact:
Ingestion:
Wash with soap and water.
Skin Contact:
Section 5: Fire Fighting Measures
Suitable extinguishing media: CO2, dry chemical, foam or water.
Fire Fighting Instructions: Generally by sprinkling or extinguisher
Special protective equipment for fire fighters: none
UEL: n/a
Burning rate: N/a
LEL: n/a
your document management partner
MATERIAL SAFETY DATA SHEET
Page 3 of 3
CP-458
Section 14: Transportation Information
International regulations:
RID/ADR
DOT 49 CFR
ADNR
Not applicable
ICAO-TI/ATA-DGR
UN Classification Number
IMDG Code
Not applicable
Not applicable
Not applicable
Not applicable
Not applicable
Specific precautionary transport measures: Avoid direct sunlight. Do not keep over 35°C (95°F).
Specific material to avoid: None in normal use.
Product Label: Black Toner Type 140
Section 15: Regulatory Information
Section 16: Miscellaneous Information
Regulation:
No information available
Judgment as to the suitability of information contained herein for user’s purposes is the responsibility of the purchaser.
Therefore, although reasonable care has been taken in the preparation of this information, Lanier Worldwide, Inc. extends no
warranties, makes no representations, and assumes no responsibility as to the accuracy or suitability of such information for
application to user’s intended purposes or for consequences of its use. All materials may present unknown hazards and
should be used with caution. Although certain hazards are described herein, we do not guarantee that these are the only
hazards that exist.
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under
normal conditions. On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the
usual precautionary measures for dealing with chemicals.
|